Application of Plantaricin as an Antimicrobial Substrate in the Milking Process to Maintain Milk Quality in Smallholder Dairy Farm

Amalina Nur Wahyuningtyas, Irma Isnafia Arief, Epi Taufik
 DOI  https://doi.org/10.14334/jitv.v26i2.2718

Abstract

Pathogenic bacterial contamination found in fresh cow's milk can be caused by poor milking management. This traditional milking process allows the milk to be contaminated from bacteria and dirt. Dyeing dairy cows using a commercial antiseptic is a common measure that can be done to prevent mastitis. Nipple immersion can be done after milking using synthetic antiseptic agents such as povidone iodine and chlorine. However, the use of synthetic antiseptics can actually cause a slight irritation and allergic effect and leave a residue. Therefore, it is hoped that the use of natural-based antiseptics can replace synthetic antiseptics. One of the natural based antiseptics that can be used is bacteriocin. This research aimed to analyze the application of the plantaricin IIA-1A5 as a substitute for synthetic antibacterial for teat dipping before milking namely microbiological tests, physicochemical tests, and pH measurements. The study was conducted using a randomized block design (RBD) with three replications. The treatment design consisted of control (without immersion), plantaricin 0.0074%, and povidone iodine 0.2%. Results showed application of plantaricin IIA-1A5 as teat dipping before milking can reduce the Total Plate Count, Escherichia coli, and Staphylococcus aureus population. The use of plantaricin IIA-1A5 as teat dipping did not change pH value and physicochemical quality (fat, SNF, lactose, and protein), which is below the Indonesian National Standard (SNI) about fresh milk. This ability is comparable to the iodine group, a synthetic antibacterial widely used by smallholder breeders in Indonesia. It is concluded that plantaricin IIA-1A5 can be used as a substitute for synthetic antibacterial (iodine group) for teat dipping before milking.

Keywords

Fresh milk, L. Plantarum IIA-1A5, Plantaricin IIA-1A5

Full Text:

PDF

References

Arief I Isnafia, Budiman C, Jenie BSL, Andreas E, Yuneni A. 2015. Plantaricin IIA-1A5 from Lactobacillus plantarum IIA-1A5 displays bactericidal activity against Staphylococcus aureus. Benef Microbes. 6:603–613. DOI: 10.3920/BM2014.0064

Arief II, Jakaria J, Suryati T, Wulandari Z, Andreas E. 2013. Isolation and characterization of plantaricin produced by Lactobacillus plantarum Strains (IIA-1A5, IIA-1B1, IIA-2B2). Media Peternak. 36:91–100.

Arief II, Jenie BSL, Suryati T, Ayuningtyas G, Fuziawan A. 2012. Antimicrobial activity of bacteriocin from indigenous Lactobacillus plantarum 2C12 and its application on beef meatball as biopreservative. J Indones Trop Anim Agric. 37:90–96.

Arief Irma Isnafia, Laksmi BS, Astawan M, Fujiyama K, Witarto AB. 2015b. Identification and probiotic characteristics of lactic acid bacteria isolated from Indonesian local beef. Asian J Anim Sci. 9:25–36.

Arief II, Wulandari Z, Sinaga ES, Situmorang DM. 2017. Application of purified bacteriocin from Lactobacillus plantarum IIA-1A5 as a bio-preservative of beef sausage. Pakistan J Nutr. 16:444–450.

Arifin M, Budiman C, Fujiyama K, Arief II. 2020. Kinetic and thermodynamic study of plantaricin IIA-1A5, a bacteriocin produced by Indonesian probiotic Lactobacillus plantarum IIA-1A5. Protein Pept Lett. 27.

[BSN] Badan Standardisasi Nasional. 2011. Definisi dan Syarat Mutu Susu Segar. Jakarta (Indones): Badan Standardisasi Nasional.

Fatmarani R, Arief II, Budiman C. 2018. Purification of bacteriocin from Lactobacillus plantarum IIA-1A5 grown in various whey cheese media under freeze dried condition. Trop Anim Sci J. 41:53–59. DOI: 10.5398/tasj.2018.41.1.53.

Flachowsky G, Franke K, Meyer U, Leiterer M, Schöne F. 2014. Influencing factors on iodine content of cow milk. Eur J Nutr. 53:351–365. DOI: 10.1007/s00394-013-0597-4.

Hata T, Tanaka R, Ohmomo S. 2010. Isolation and characterization of plantaricin ASM1: A new bacteriocin produced by Lactobacillus plantarum A-1. Int J Food Microbiol. 137:94–99. DOI: 10.1016/j.ijfoodmicro.2009.10.021.

Hu M, Zhao H, Zhang C, Yu J, Lu Z. 2013. Purification and characterization of plantaricin 163, a novel bacteriocin produced by Lactobacillus plantarum 163 isolated from traditional chinese fermented vegetables. J Agric Food Chem. 61:11676–11682. DOI: 10.1021/jf403370y.

Karpinski TM, Szkaradkiewicz AK. 2013. Characteristic of bacteriocines and their application. Polish J Microbiol. 62:223–235. DOI: 10.33073/pjm-2013-030.

Kia KW, Arief II, Sumantri C, Budiman C. 2015. Plantaricin IIA-1A5 from Lactobacillus plantarum IIA-1A5 retards pathogenic bacteria in beef meatball stored at room temperature. Am J Food Technol. 11:37–43. DOI: 10.3923/ajft.2016.37.43.

Le NTT, Bach LG, Nguyen DC, Le THX, Pham KH, Nguyen DH, Hoang Thi TTH. 2019. Evaluation of factors affecting antimicrobial activity of bacteriocin from Lactobacillus plantarum microencapsulated in alginate-gelatin capsules and its application on pork Mmeat as a bio-preservative. Int J Environ Res Public Health. 16:1017. DOI: 10.3390/ijerph16061017.

Lv X, Du J, Jie Y, Zhang B, Bai F, Zhao H, Li J. 2017. Purification and antibacterial mechanism of fish-borne bacteriocin and its application in shrimp (Penaeus vannamei) for inhibiting Vibrio parahaemolyticus. World J Microbiol Biotechnol. 33:156. DOI: 10.1007/s11274-017-2320-8.

Mahardhika O, Sudjatmogo, Suprayogi T. 2012. Tampilan total bakteri dan pH pada susu kambing perah akibat dipping desinfektan yang berbeda. Anim Agric J. 1:819–828.

Marsh AJ, Hill C, Ross RP, Cotter PD. 2014. Fermented beverages with health-promoting potential: Past and future perspectives. Trends Food Sci Technol. 38:113–124. DOI: 10.1016/j.tifs.2014.05.002.

Maturin L, Peeler JT. 2001. Aerobic Plate Count. In: Bact Anal Method. Washington DC (USA): Food and Drugs Administration.

Mirdhayati I, Handoko J, Putra K. 2008. Mutu Susu Segar di UPT Ruminansia Besar Dinas Peternakan Kabupaten Kampar Provisi Riau. J Peternak. 5:14–21.

Prihutomo S, Etza Setiani B, Wahyu Harjanti D. 2015. Screening sumber cemaran bakteri pada kegiatan pemerahan susu di peternakan sapi perah rakyat Kabupaten Semarang. J Ilmu-Ilmu Peternak. 25:66–71. DOI: 10.21776/ub.jiip.2015.025.01.10.

Sihombing DE, Arief II, Budiarti S. 2015. Application of antimicrobial agents produced by Lactobacillus plantarum IIA-1A5 as natural preservative on beef during room temperature storage. Adv J Food Sci Technol. 8:251–255. DOI: 10.19026/ajfst.8.1503.

Siswara HN, Arief II, Wulandari Z. 2019. Plantarisin Asal Lactobacillus plantarum IIA-1A5 sebagai Pengawet Alami Daging Ayam Bagian Paha pada Suhu Refrigerator. J Ilmu Produksi dan Teknol Has Peternak. 7:123–130. DOI: 10.29244/jipthp.7.3.123-130.

Soenarno MS, Arief II, Sumantri C, Taufik E, Nuraida L. 2020. Karakterisasi Plantarisin IIA-1A5 sebagai Antimikroba dan Evaluasi Aktivitas Sediaan Kering Beku Terenkapsulasi. J Apl Teknol Pangan. 9:30–37. DOI: 10.17728/jatp.5480.

Soenarno MS, Sumantri C, Taufik E, Nuraida L, Arief II. 2019. Lactobacillus plantarum IIA-1A5 Fermentation Patterns by Using whey, buttermilk and Whey Enriched by Skimmed Milk as Growth Media. Pakistan J Nutr. 18:288–295. DOI: 10.3923/pjn.2019.288.295.

Steel RGD, Torrie JH. 1996. Principles and Procedures of Statistics A Biometrical Approach. 3rd ed. New York (USA): McGraw Hill Book Company Inc.

Todorov SD, Holzapfel W, Nero LA. 2016. Characterization of a novel bacteriocin produced by Lactobacillus plantarum ST8SH and some aspects of its mode of action. Ann Microbiol. 66:949–962. DOI: 10.1007/s13213-015-1180-4.

Wen LS, Philip K, Ajam N. 2016. Purification, characterization and mode of action of plantaricin K25 produced by Lactobacillus plantarum. Food Control. 60:430–439. DOI: 10.1016/j.foodcont.2015.08.010.

Zacharof M, Lovitt R. 2012. Bacteriocins produced by lactic acid bacteria a review article. APCBEE Procedia. 2:50–56. DOI: 10.1016/j.apcbee.2012.06.010.

Refbacks

  • There are currently no refbacks.

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.



Bookmark and Share